An Experimental study on usage of hollow glass spheres (HGS) for reducing mud density in low pressure reservoirs and lost circulation zones

Download
2014
Arı, T. Çağrı
Drilling fluid is a fluid mixture that is used in oil and gas drilling operations. Generating hydrostatic pressure, carrying cuttings to the surface and maintaining wellbore stability is essential for a drilling fluid with its other important functions. For low pressure reservoirs, hydrostatic pressure that drilling fluid generated should be low. To achieve that, drilling fluid density should be lowered. However, use of drilling fluids with higher density than required could cause partial or complete loss of drilling fluid into the formation which may cause serious problems. To obtain lower mud densities, methods such as air/dust drilling can be used or oil based muds can be preffered. But for enviromental reasons and cost issues, Hollow Glass Spheres (HGS) is a serious alternative. This study aims to find proper HGS type with a convenient composition in a water based mud. In this study, HGS is used to obtain a density as low as 6.88 ppg which is needed to balance the formation pressure in a low pressure reservoir. Among HGSs with different pressure resistance, HGS5000 and HGS8000X are tested because of the maximum pressure to be encountered in the well is lower than 5000 psi. HGS is selected based on its improved mud properties such as fluid loss, rheological properties, filter cake quality, pH and gelation. After selecting the proper HGS type, laboratory tests are conducted with different water based fluid systems such as KCl-Polymer mud, Polymer based mud and Flo-Pro mud with different concentrations of HGS. Polymer based mud with HGS at rating of 5000 psi showed the best performance in cuttings carrying capacity which can be interpretted from rheological properties. Polymer based mud with HGS5000 has the lowest fluid loss value by optimizing CaCO3 concentration and has the best filter cake qualities: thin and impermeable. Gelation and pH values of the selected drilling fluid are observed. Polymer optimization for the selected drilling fluid with selected HGS is conducted and particle size analysis is also in the content of this study.

Suggestions

An Experimental study of silicate polymer gel systems to seal shallow water flow and lost circulation zones in top hole drilling
Ay, Ahmet; Kök, Mustafa Verşan; Gücüyener, İsmail Hakkı; Department of Petroleum and Natural Gas Engineering (2012)
Shallow water flow and lost circulation are frequently encountered problems during drilling top holes of oil, gas or geothermal wells. Plenty of methods have been applied to overcome these problems. Placement of silicate based gel systems is one of the oldest methods to seal such undesired zones. For this study, sodium-silicate based gel system is investigated experimentally. This gel system is deliberately delayed multi-component system mixed as a uniform liquid at the surface but desired to form strong ge...
An Experimental study of particle size and concentration effects of calcium carbonate on rheological and filtration properties of drill-in fluids
Odabaşı, Aydın; Kök, Mustafa Verşan; Gücüyener, İ. Hakkı; Department of Petroleum and Natural Gas Engineering (2015)
Specially designed non-damaging Drill-In Fluids (DIF) are being effectively applied for drilling depleted zones worldwide. Shape, particle size distribution and concentration of materials like calcium carbonate (CaCO3) are key parameters determining the effectiveness of DIF. In this study, 3 different sized and 5 different concentrations CaCO3 are used to examine the effects of these factors on rheology and fluid loss of DIF. Sized calcium carbonates are used as major particles in different concentrations a...
Experimental investigation of cuttings transport in horizontal wells using aerated drilling fluid
Gül, Sercan; Parlaktuna, Mahmut; Kuru, Ergün; Department of Petroleum and Natural Gas Engineering (2017)
A new experimental approach has been introduced in this thesis for the cuttings transport in horizontal wellbores with the introduction of drag reducers into the aerated drilling fluids. Advanced Flow Loop System (annular test section of 21 ft. long 2.91-in. ID transparent casing and 1.85 in. OD inner drill pipe) in Middle East Technical University Petroleum and Natural Gas Engineering Department have been used for the experiments. The liquid phase has been water and water-PHPA copolymer mixture where the g...
An Experimental study on the effects of different chloride sources on the properties of API Class G cement
Ramazanoğlu, Özge; Yaman, İsmail Özgür; Akın, Serhat; Department of Cement Engineering (2014)
In the petroleum industry, oil well cements are used in the form of slurries during the construction of oil or natural gas wells. Preserving the integrity of the well and the casing, providing zonal isolation are some of the uses of these special cements. Oil well cement slurries used in the petroleum industry are subjected to different exposure conditions than ordinary Portland cement slurries used in the construction industry. Therefore, oil well cements are required to possess different engineering prope...
Determination of cuttings transport properties of gasified drilling fluids
Ettehadi Osgouei, Reza; Mehmetoğlu, Mustafa Tanju; Özbayoğlu, Mehmet Evren; Department of Petroleum and Natural Gas Engineering (2010)
The studies conducted on hole cleaning have been started with single phase drilling fluids for vertical holes in 1930’s, and have reached to multiphase drilling fluids for directional and horizontal wells today. The influence of flow rate and hole inclination on cuttings transport has been well understood, and many studies have been conducted on effective hole cleaning either experimentally or theoretically. However, neither the hydraulic behavior nor the hole cleaning mechanism of gasified drilling fluids ...
Citation Formats
T. Ç. Arı, “An Experimental study on usage of hollow glass spheres (HGS) for reducing mud density in low pressure reservoirs and lost circulation zones,” M.S. - Master of Science, Middle East Technical University, 2014.